Lingering Legacy: Millions of Toxic Solar Panels That Can’t Be Recycled Destined for Landfills

Around the globe, millions upon millions of solar panels have reached their use by dates; they can’t be recycled, which means they’re destined for the local dump.

Each panel is a veritable toxic cocktail of gallium arsenide, tellurium, silver, crystalline silicon, lead, cadmium and other heavy metals. As the stuff leeches into the water table, it’s not difficult to imagine the effect on water supplies, the environment and human health.

And it’s not just filling up landfill with toxic sludge – in the mother of all ironies – while they’re above ground, solar panels are sending the mercury northward, adding 3-4°C to the average temperature of the environment in which they are situated.

Well, it all seemed like such a good idea, at the time.

Duggan Flanakin deals with that and a number of other matters which tend to take the shine off solar power.

Solar panels generate mountains of waste – They also heat the planet, blanket wildlife habitats and cause other ecological damage
Watts Up With That?
Duggan Flanakin
19 September 2020

The problem of solar panel waste is now becoming evident. As environmental journalist Emily Folk admits in Renewable Energy Magazine, “when talking about renewable energy, the topic of waste does not often appear.” She attributes this to the supposed “pressures of climate change” and alleged “urgency to find alternative energy sources,” saying people may thus be hesitant to discuss “possible negative impacts of renewable energy.”

Ms. Folk admits that sustainability requires proper e-waste management. Yet she laments, “Solar presents a particular problem. There is growing evidence that broken panels release toxic pollutants … [and] increasing concern regarding what happens with these materials when they are no longer viable, especially since they are difficult to recycle.”

This is the likely reason that (except in Washington state), there are no U.S. mandates for solar recycling. A recent article in Grist reports that most used solar panels are shipped to developing countries that have little electricity and weak environmental protections, to be reused or landfilled.

The near-total absence of end-of-life procedures for solar panels is likely a byproduct of the belief (and repeated, unsupported assertion) that renewable energy is “clean” and “green.” Indeed, Mississippi Sierra Club state director Louie Miller recently claimed that unlike fossil fuels and nuclear energy, “Sunshine is a free fuel.” Well, sunshine is certainly free and clean. However, there is a monumental caveat.

Harnessing sunshine (and wind) to serve humanity is not free – or clean, green, renewable or sustainable.

The 1977 Surface Mining Control and Reclamation Act mandates that new surface coal mines include plans and set aside funds for full reclamationof mine properties. The law also sets standards for restoring abandoned mine lands. There is nothing akin to this for solar facilities and wastes.

Similarly, the 1980 Superfund law (Comprehensive Environmental Response, Compensation and Liability Act) created a tax and trust fund to pay for preventing and fixing actual or threatened releases of hazardous substancesthat could endanger public health or the environment. Again, still nothing for solar.

The 1982 Nuclear Waste Policy Act prioritizes deep geologic repositories for safe storage and/or disposal of radioactive waste. Unfortunately, 25 years after being designated as the disposal site, Nevada’s Yucca Mountain has never opened, because of conflicts among politicians, locals, anti-nuclear activists, government officials and the nuclear industry. The U.S. still stores its nuclear waste at 75 scattered sites, including some near New York City, New Orleans and Chicago. For solar no steps have been taken.

While coal, nuclear, and petrochemical companies must come up with detailed, costly plans for dealing with real or potential negative consequences of their operations, solar (and wind) companies have been rewarded with massive subsidies and absolutely no disposal standards or requirements.

No government grants require that solar companies set aside money to dispose of, store or recycle wastes generated during manufacturing or after massive solar “farms” have ceased functioning and been torn down. Solar (and wind) customers are likewise not charged for waste cleanup, disposal, or reuse and recycling. This and the massive subsidies distort and hide the true costs of solar power.

But reality is starting to catch up. Disposal (or recycling) costs will have to be paid, ultimately by consumers. The more solar panels we have (likely billions within a few years), the higher those costs will be. Consumers in states like California that have committed to heavy reliance on solar (and wind) energy (and already have the nation’s highest energy bills) will have to pay even more.

California is also facing a secondary problem from the proliferation of subsidized industrial solar installations. A 2015 study by Stanford University and the Carnegie Institution for Science found that nearly a third of the state’s solar development is occurring on former cropland, where many farmers are shifting from growing crops to using their land to generate electricity – rather than letting it become wildlife habitat. As Big Solar also moves into natural areas, California is losing even more habitat and scenic land, while the integrity of state and national parks suffers from the nearby glare of countless solar panels and towering transmission lines to distant cities.

The Stanford study highlights another problem: localized higher temperatures. It found it will take an area the size of South Carolina filled with solar arrays to meet California’s goal of cutting greenhouse gas emissions 80% below 1990 levels by 2050. [It would take at least eight South Carolinas if the California mandate were extended nationwide.]

Other research has found that these large-scale solar power plants raise local temperatures, creating a significant solar heat island effect. Temperatures around one solar power plant were 5.4o-7.2 °F (3o-4°C) warmer than nearby wildlands. Imagine such manmade “global warming” across 20 million acres (South Carolina) or 160 million acres (Texas), to meet California or U.S. greenhouse gas reduction goals!

Australia is already coping with this unwelcome reality. Not until 2018 did Aussie environment ministers mandate fast-track development of new product stewardship schemes for photovoltaic (PV) solar panels, like those television and computer manufacturers and retailers have had to comply with since 2011.

Total Environment Centre director Jeff Angel admitted that setting standards for life-of-product management for solar panels was “long overdue,” and that the 30-year delay in imposing standards revealed a “fundamental weakness” in Australia’s waste policies. He further noted that while solar panels contain hazardous substances, Aussies are “sending hundreds of thousands of e-waste items to landfills” and creating significant pollution problems. And Australia has less than a tenth of the U.S. population!

Since 2002, the European Union’s Waste Electrical and Electronic Equipment (WEEE) Directive has required that original producers of e-wastes guarantee and pay for taking back and recycling their wastes, so that end-user consumers aren’t surprised by additional disposal costs.

However, PV solar panel waste was not included in this mandate until July 2012 – and “some uncertainty remains” about the cutoff date for such wastes, because the directive has yet to be implemented in national laws. Producer financing of PV waste treatment thus cannot be applied to older solar panels. So who will pay? And how much?

Ms. Folk and others look to waste-to-energy plants, and indeed the EU does send much of its solar panel waste to incinerators – which many environmentalists oppose. Landfilling is not a viable option in the U.S., because toxins could leach out. Unscrupulous companies ship solar panel waste to developing nations, but that is a stopgap solution that is environmentally irresponsible.

Tao Meng, lead author of a new study, says “the big blind spot in the U.S. for recycling is that the cost far exceeds the revenue” – by nearly 10-to-1, especially when including transportation costs. Chemicals must be used to remove silver and lead from silicon modules before they can be safely placed in landfills, Meng notes.

The problem of solar panel waste will continue to grow as more panels reach their end of life. Four years ago the International Renewable Energy Agency estimated there were already about 250,000 metric tons of solar panel waste worldwide – and that total will explode to 78 million metric tons by 2050!

So when you read that solar energy is already cheaper than natural gas, don’t be fooled. They are omitting the pollution and disposal costs, as well as habitat losses, solar heat islands, and the need for backup power generation or batteries – to lowball the true costs of intermittent, season, latitude and weather-dependent solar. We need some honest math now, before it’s too late to turn back.
Watts Up With That?

6 thoughts on “Lingering Legacy: Millions of Toxic Solar Panels That Can’t Be Recycled Destined for Landfills

  1. The Definition of Insanity is doing the same thing over expecting different results..
    This is the agenda of Political Correctness. Many entities have now recognized the Failure of sucking up to the climate change program, only to have to shovel out much more funds to make up for the catastrophic end failure .
    It’s a money laundering program with no solution to it..
    Only the politicians and the companies they support make money.
    It robs the people of good resources!

  2. I don’t understand why solar panels expire? Isn’t there different kinds of panels? Some are better than others?

    1. Photovoltaic cells are essentially a platform for a chemical reaction in the presence of solar radiation, over time the ability of the cells to convert solar radiation ie photons into electrical energy diminishes. The cell eventually ceases to produce any power at all. Then it’s off to the local dump.

      1. So in other words or maybe the same words THERE IS A CHEMICAL REACTION in solar energy production. This makes me wonder, if there is a chemical reaction in solar panels, could there be emissions we are not aware of? Are there chemical fumes like from what we smell in stores that have cheap vinyl office supplies and plastic toys? No one seems to pay any attention to these toxins flooding the air instead claiming we are all going to die from carbon dioxide blankets of nothing. Certainly these chemicals embedded in solar will of course end up in the ground in land fills everywhere we do understand this but it’s intriguing to consider these chemical reactions and then what is left at their end of life. The burning of hydrocarbons is also a chemical reaction which emits clean carbon dioxide that is easily managed by nature and recycled by all plant life everywhere. Hmm.

  3. There is only one way to sensibly deal with potential global warming ….. ADAPT.

    That is what we have been doing for 10s of thousands or years.

    Why mess with success.

  4. Aren’t human beings intelligent! We have so much to be proud about! Maybe Al Gore will have the solution and get another Nobel Prize? Lithium is on the way, we better find a way to move to Mars fast, then ruin that planet.

Leave a Reply to Paul Carlson Cancel reply

Fill in your details below or click an icon to log in: Logo

You are commenting using your account. Log Out /  Change )

Facebook photo

You are commenting using your Facebook account. Log Out /  Change )

Connecting to %s